基于多场耦合的电机暂态温度场研究

doi:10.16180/j.cnki.issn1007-7820.2020.05.003

电子科技 ›› 2020, Vol. 33 ›› Issue (5): 15-20.doi: 10.16180/j.cnki.issn1007-7820.2020.05.003

基于多场耦合的电机暂态温度场研究

宋贺^1,²,吴尧辉^1,²,吴昊珍³

1. 河南理工大学电气工程与自动化学院,河南焦作 454000
2. 直驱电梯-河南省工程技术研究中心,河南焦作 454000
3. 郑州工商学院,河南郑州 451400

收稿日期:2019-03-12 出版日期:2020-05-15 发布日期:2020-06-02
作者简介:宋贺(1993-),男,硕士研究生。研究方向:电机与电器。|吴尧辉(1964-),男,高级工程师。研究方向:电机与电器,电力系统继电保护等。
基金资助:
国家自然科学基金(61340015);教育部协同育人项目(201701056027);教育部协同育人项目(201702064052);教育部创新创业联合基金(201802060039);河南省教育厅自然bepaly手机下载计划项目(2010A470003);河南省教育厅自然bepaly手机下载计划项目(2009B470003)

Research on Transient Temperature Field of Motor Based on Multifield Coupling

SONG He^1,²,WU Yaohui^1,²,WU Haozhen³

1. School of Electrical Engineering and Automation,Henan Polytechnic University, Jiaozuo 454000,China
2. Direct Drive Elevator-Engineering Technology Research Center of Henan Province, Jiaozuo 454000,China
3. Zhengzhou Technology and Business University,Zhengzhou 451400,China

Received:2019-03-12 Online:2020-05-15 Published:2020-06-02
Supported by:
National Natural Science Foundation of China(61340015);Ministry of Education Collaborative Education Project(201701056027);Ministry of Education Collaborative Education Project(201702064052);Ministry of Education Innovation and Entrepreneurship Fund(201802060039);Natural Science Research Program of Education Department of Henan Province(2010A470003);Natural Science Research Program of Education Department of Henan Province(2009B470003)

摘要/Abstract

摘要：

针对复杂工况下电机不稳定发热引起的温度场暂态计算问题,根据不稳定发热的规律建立电磁场与温度场的二维耦合模型。文中依据小型式异步电机的结构特点,进行电磁场-热场二维模型的结构参数、边界条件参数、材料的电、热物理参数的计算、等效及配置;依据复杂工况下发热变化的规律,进行耦合频率、热源耦合方式的设计及相关参数计算配置,实现不稳定负载下电机的暂态温度场计算并考察电机各部分的实际最高温度分布状况。基于实验平台的方案设计和搭建,进行温升实验。通过对比分析电机暂态温度场的仿真和实验数据,验证了二维模型参数等效的合理性和多场耦合法能够准确地计算复杂工况下电机全暂态温度场。

关键词: 复杂工况, 二维模型, 不稳定负载, 暂态温度场, 参数等效, 多场耦合

Abstract:

To solve the transient calculation of temperature field problem caused by unstable heating of the motor under complex working conditions, a two-dimensional coupling model of electromagnetic field and temperature field was established according to the law of unstable heat. Based on the structural characteristics of small type asynchronous motor, the structural parameters, boundary condition parameters, electrical and thermal physical parameters calculation, equivalent and configuration of the electromagnetic field-thermal field two-dimensional model were performed. According to the law of heating variation under complex working conditions, the coupling frequency and heat source coupling mode were designed, and the relevant parameters were calculated and configured. The transient temperature field calculation of the motor under unstable load was realized, and the actual maximum temperature distribution of each part of the motor was investigated. The temperature rise experiment was carried out through the scheme design and construction of the experimental platform. The simulation and experimental results of the transient temperature field of the motor showed that the rationality of parameters equivalence of the two-dimensional model and multi-field coupling method could accurately calculate the full transient temperature field of the motor under complex conditions.

Key words: complex working condition, two-dimensional model, unstable load, transient temperature field, parameters equivalence, multi-field coupling

中图分类号:

TP391.9

宋贺,吴尧辉,吴昊珍. 基于多场耦合的电机暂态温度场研究[J]. 电子科技, 2020, 33(5): 15-20.

SONG He,WU Yaohui,WU Haozhen. Research on Transient Temperature Field of Motor Based on Multifield Coupling[J]. Electronic Science and Technology, 2020, 33(5): 15-20.

图/表 12

表1

图1

图2

表2

表3

图3

图4

图5

图6

表4

图7

图8

参考文献 16

[1]	路玲, 王淑旺 . 永磁同步电机全域温度场分析与水道优化设计[J]. 电机与控制应用, 2018,45(5):52-57.
	Lu Ling, Wang Shuwang . Analysis of temperature field and optimal design of watercourse for permanent magnet synchronous motor[J]. Machines & Control Application, 2018,45(5):52-57.
[2]	上官璇峰, 蒋思远, 周敬乐 , 等. 双转子双鼠笼永磁感应电机三维全域温度场分析[J]. 电机与控制学报, 2018,22(11):58-66.
	Shangguan Xuanfeng, Jiang Siyuan, Zhou Jingle , et al. Three-dimensional global temperature field analysis of double-rotor double-squirrel cage permanent magnet induction motor[J]. Electric Machines and Control, 2018,22(11):58-66.
[3]	谢颖, 王泽, 单雪婷 , 等. 基于多场量的笼型感应电机三维瞬态磁热固耦合计算分析[J]. 中国电机工程学报, 2016,36(11):3076-3084.
	Xie Ying, Wang Ze, Shan Xueting , et al. Calculation and analysis of three-dimensional transient magneto thermal solid coupling of cage induction motor based on multi-field quantities[J]. Proceedings of the CSEE, 2016,36(11):3076-3084.
[4]	陈华毅 .异步电机三维电磁场及温度场耦合仿真分析[J].电机与控制应用, 2015,42(1) 42-47.
	Chen Huayi . Simulation analysis of three-dimensional electromagnetic field and temperature field coupling of asynchronous motor[J]. Machines & Control Application, 2015,42(1):42-47.
[5]	宋聪 . 基于耦合场的永磁伺服电机温升计算研[D]. 沈阳:沈阳工业大学, 2018.
	Song Cong . Research on temperature rise calculation of permanent magnet servo motor based on coupling field[D]. Shenyang:Shenyang University of Technology, 2018.
[6]	权艳娜, 胡博, 高俊丽 , 等. 某弹用直流无刷电机温度场分析及其验证[J]. 微电机, 2018,51(10):60-63.
	Quan Yanna, Hu Bo, Gao Junli , et al. Temperature field analysis and verification of a brushless dc motor for missile[J]. Micromotosr, 2018,51(10):60-63.
[7]	吴尧辉, 张建强, 刘思 . 参数修正的场路结合法仿真异步机起动性能[J]. 计算机仿真, 2017,34(7):188-190.
	Wu Yaohui, Zhang Jianqiang, Liu Si . Simulation of starting performance of asynchronous machine by field path combination with parameter correction[J]. Computer Simulation, 2017,34(7):188-190.
[8]	王奇, 李英娜, 万小容 , 等. 基于Maxwell的干式铁心电抗器绕组涡流损耗分析[J]. 电子科技, 2018,31(7):1-3,14.
	Wang Qi, Li Yingna, Wan Xiaorong , et al. Eddy current loss analysis of winding of dry core reactor based on Maxwell[J]. Electronic Science and Technology, 2018,31(7):1-3,14.
[9]	王天煜, 温福强, 张凤阁 , 等. 兆瓦级高速永磁电机转子多场耦合强度分析[J]. 电工技术学报, 2018,33(19):4508-4516.
	Wang Tianyu, Wen Fuqiang, Zhang Fengge , et al. Multi-field coupling strength analysis of the rotor of megawatt high-speed permanent magnet motor[J]. Transactions of China Electrotechnical Society, 2018,33(19):4508-4516.
[10]	廖传杰 . 电动汽车轮毂电机设计及电磁热分析研究[D]. 南昌:华东交通大学, 2018.
	Liao Chuanjie . Research on hub motor design and electromagnetic thermal analysis of electric vehicles[D]. Nanchang:East China Jiaotong University, 2018.
[11]	刘金辉, 李丹妮, 蔡巍 . 车用永磁电机在不同工况下的温升分析[J]. 微特电机, 2018,46(6):5-8,14.
	Liu Jinhui, Li Dani, Cai Wei . Analysis of temperature rise of automotive permanent magnet motor under different working conditions[J]. Small & Special Electrica, 2018,46(6):5-8,14.
[12]	陈起旭, 梁得亮, 徐俊 , 等. 盘式交流永磁同步电机温升影响因素研究[J]. 电机与控制学报, 2018,22(3):33-41.
	Chen Qixu, Liang Deliang, Xu Jun , et al. Research on factors affecting temperature rise of pan AC permanent magnet synchronous motor[J]. Electric Machines and Control, 2018,22(3):33-41.
[13]	朱高嘉, 朱英浩, 佟文明 , 等. 有限公式温度场计算技术及其在永磁电机分析中的应用[J]. 中国电机工程学报, 2017,37(S1):152-161.
	Zhu Gaojia, Zhu Yinghao, Tong Wenming , et al. Finite formula temperature field calculation technology and its application in permanent magnet motor analysis[J]. Proceedings of the CSEE, 2017,37(S1):152-161.
[14]	翟景森, 康娟, 杨泗鹏 , 等. 高转矩密度电机温度场分析及冷却系统优化[J]. 微特电机, 2017,45(12):35-37,44.
	Zhai Jingsen, Kang Juan, Yang Sipeng , et al. Temperature field analysis and cooling system optimization of high torque density motor[J]. Small & Special Electrical Machines, 2017,45(12):35-37,44.
[15]	张琦, 李增亮, 董祥伟 , 等. 水下电机损耗加载方式及温度场耦合分析[J]. 电工技术学报, 2018,33(5):1007-1014.
	Zhang Qi, Li Zengliang, Dong Xiangwei , et al. Coupling analysis of loss loading mode and temperature field of under water motor[J]. Transactions of China Electrotechnical Society, 2018,33(5):1007-1014.
[16]	李立毅, 张江鹏, 闫海媛 , 等. 高功率密度电机三维温度场计算及导热优化研究[J]. 中国电机工程学报, 2016,36(13):3642-3650,3384.
	Li Liyi, Zhang Jiangpeng, Yan Haiyuan , et al. Calculation of three-dimensional temp Herature field and thermal conductivity optimization of high-power density motor J]. Proceedings of the CSEE, 2016,36(13):3642-3650,3384.

参数名称	参考值	参数名称	参数值
额定功率/W	100	气隙长度/mm	0.18
额定电压/V	220	定子槽数	24
额定电流/A	0.5	转子槽数	30
额定转速/r·min^-1	1 420	定子外径/mm	120
铁心长度/mm	50	定子内径/mm	71.16

负载/Nom	时间/min	求解模型	时间	步长
额定负载	5	电磁场	420 ms	1 ms
1.3倍负载	5	温度场	176 min	1 min
1.5倍负载	1	耦合模型	176 min	5 min

参数	数值
时间/min	44	88	132	176
转子/℃	56.2	66.7	72.3	75.9
槽内下/℃	52.3	62.2	67.7	71.1
槽内中/℃	53.5	63.5	69.0	72.5
槽中顶/℃	53.0	62.9	68.4	71.9
端齿顶℃	51.6	61.6	66.9	70.4
轭外中/℃	50.2	59.9	65.1	68.5
外壳/℃	48.7	57.9	62.9	66.2

参数	数值
时间/min	44.0	88.0	132.0	176.0
转子/℃	55.8	65.7	72.3	75.3
槽内下/℃	51.4	62.1	67.8	71.0
槽内中/℃	52.5	63.4	69.4	72.3
槽中顶/℃	52.0	62.8	68.4	71.8
端齿顶℃	50.7	61.3	66.9	70.3
轭外中/℃	49.0	59.5	65.0	68.3
外壳/℃	46.9	56.8	62.1	64.9

基于多场耦合的电机暂态温度场研究

Research on Transient Temperature Field of Motor Based on Multifield Coupling

RichHTML

PDF (PC)

赞

可视化

摘要/Abstract

引用本文

使用本文

图/表 12

参考文献 16

相关文章 15

Metrics

本文评价

推荐阅读 7

[1]	方鑫,吴尧辉,吴昊珍. 基于Fluent的电机温度场计算[J]. 电子科技, 2021, 34(12): 30-35.
[2]	徐洋洋,伞红军,陈久朋,谢飞亚,魏顺祥,王汪林,刘亮,陈佳. FL-DLight3-4000激光器激光熔覆过程温度场数值模拟分析[J]. 电子科技, 2021, 34(11): 1-10.
[3]	陈胜利,王新掌,许孝卓. 永磁同步电机失磁故障电磁仿真分析[J]. 电子科技, 2021, 34(10): 32-37.
[4]	刘亚泽,张帅,郭梁,陈昕彤,武健康. 基于真实头模型的经颅磁声电刺激感应电流密度仿真分析[J]. 电子科技, 2021, 34(6): 17-22.
[5]	方鑫,吴尧辉,宋贺. 异步电机起动电磁仿真分析[J]. 电子科技, 2021, 34(6): 61-66.
[6]	任新瑞,马立新. 基于模糊PID负荷跟踪型主蒸汽温度控制系统研究[J]. 电子科技, 2021, 34(5): 18-23.
[7]	吴其霖,谭康伯,路宏敏. 便携式机箱内部PCB间微带线的耦合特性分析[J]. 电子科技, 2021, 34(3): 1-5.
[8]	何忠霖,周萍. 基于径向基神经网络退役锂电池分选研究[J]. 电子科技, 2021, 34(2): 38-44.
[9]	熊士婷,张玉金,刘婷婷,方翔宇. 基于最优颜色通道的图像拼接检测[J]. 电子科技, 2020, 33(12): 49-53.
[10]	黄鹏,郑岳久,高寒,来鑫. 一种锂电池多模组联合均衡系统的设计[J]. 电子科技, 2020, 33(6): 40-45.
[11]	万幸,刘美红,孙军锋,王学良. 螺旋槽位置特征对气膜密封性能影响的仿真研究[J]. 电子科技, 2020, 33(6): 69-73.
[12]	陈宇,陈龙. 复杂平面多孔模型的等几何分析[J]. 电子科技, 2020, 33(5): 38-44.
[13]	张雁飞,杜茂华,章孝琴,程正. 基于UG二次开发的齿轮仿真加工与模态分析[J]. 电子科技, 2019, 32(10): 7-12.
[14]	祁涛,白国振,江鸿潮. 基于Simulink的电动伺服加载系统仿真建模研究[J]. 电子科技, 2019, 32(8): 1-6.
[15]	孙丽萍,张希萌,何睿,李佳琪. 基于SVM的近红外黑木耳多糖含量分类[J]. 电子科技, 2019, 32(8): 16-21.